From: Lany Visoski
To: "jeffrey E." <jeevacation®gmail.com>
Subject: Re: buzz on GIV SN 1085 [1111722:740313]
Date: Wed, 10 Jun 2015 03:18:38 +0000
Yes,. It would be good to exercise the Boeing.
Plus Gulfstream installed new ADC which is working good, on GIV
Except,.
We accomplished a pitot static check which is required after ADC install, we have an airspeed split of 6kts
between capt and copilot airspeed„ avionics thinks it could be moisture in the lines, they are troubleshooting at
this time„
Will keep you posted
Thx
Lany
Sent from my iPhone
On Jun 9, 2015, at 11:07 PM, jeffrey E. <jeevacation@gmail.com> wrote:
should we fly to 727 to lsj, give it some flying time?
On Tue, Jun 9, 2015 at 8:31 PM, Larry Visoski c wrote:
Jury struts are the rods that hold the lower cowl in place when it's open, or lowered,.
There are two, one fwd and aft on the cowl,. These rods sometimes contact the engine transferring engine
fibe to airframe.
During islip Mx last year these were inspected, when we changed isolation engine mounts. We are double
checking at this time
Thx
Lany
Sent from my iPhone
On Jun 9, 2015, at 4:43 PM, jeffrey E. <jeevacation@gmail.com> wrote:
jury struts???
On Tue, Jun 9, 2015 at 4:37 PM, Larry Visoski <Ma , wrote:
Work recommendations from tech-support in Savannah, is it approved to comply with below ?
Return to service 3pm tomorrow
EFTA00686083
Thx
Larry
Sent from my iPhone
Begin forwarded message:
From: "Kessler, Barry"
Date: June 9, 2015 at 4:15:41 PM EDT
To: "Visoski"
Subject: bum on GIV SN 1085 11111722:740313]
Larry,
We have a couple of ideas.
I. Can be accomplished immediately:
In the Engine Mount Vibration Isolator R&I there is a picture of what we affectionately call the dogbone.
In the GIVAMM 71.01.00 page 401 is Engine Mount Vibration Isolators R & I (not using the MSG-3 AMM) for my reference.
There is a picture of the dogbone on page 403.
It is called "link" in the picture.
This link while you are viewing the engine from the side with the upper cowl open, must not be leaning left or right, because it
will be making contact with adjacent surface.
It must be perfectly perpendicular so-to-speak.
This link will stay where it was last positioned while the weight was off the engine with a crane.
You will have to take the weight off the engine to move the link and make it straight so it is not leaning left or right touching the
adjacent surface.
Once you place the weight back on the engine, it will stay in place till next time. It will not move.
2. When your flight schedule permits;
GIV AMM 71.00.00 bottom of page 601 begins Powerplant - Internal Inspection to page 604.
This inspection will take care of inspecting fixed cowl (truly floating cowl) and other possible chaff areas.
Even the jury struts (holds lower doors open) can contact the PLA transducers and cause a vibration, so check this as well.
Make sure during the inspection of the floating cowl there is no sign of chaff anywhere on the floating cowl next to engine.
As the engine spools up to power, it moves due to torque, and it may chaff at higher settings and not chaff when the power
comes back.
So if you see light during the inspection that is not good enough, it may be chaffing with the power forward and not chaffing
when the power is back.
The floating cowl chaff and the dogbone checks are first and foremost.
Thank you,
Barry Kessler
Gulfstream Technical Operations
Large Cabin Mechanical Systems
(Direct
(Toll Free)
This e-mail message, including all attachments, is for the sole use of the intended recipient(s) and may
contain Personal Information under General Dynamics policy CP 07-105 and/or legally privileged and
confidential information. Any Personal Information can be accessed only by authorized personnel of
General Dynamics and its approved service providers and may be used only as permitted by General
Dynamics and its policies. Contractual restrictions apply to third parties. If you are not an intended
recipient, you are hereby notified that you have either received this message in error or through
EFTA00686084
interception, and that any review, use, distribution, copying or disclosure of this message or its
attachments is strictly prohibited and is subject to criminal and civil penalties. All personal messages
express solely the sender's views and not those of Gulfstream Aerospace Corporation.
If you received this message in error, please contact the sender by reply e-mail and destroy all copies of
the original message.
please note
The information contained in this communication is
confidential, may be attorney-client privileged, may
constitute inside information, and is intended only for
the use of the addressee. It is the property of
JEE
Unauthorized use, disclosure or copying of this
communication or any part thereof is strictly prohibited
and may be unlawful. If you have received this
communication in error, please notify us immediately by
return e-mail or by e-mail to jeevacation@gmail.com, and
destroy this communication and all copies thereof,
including all attachments. copyright -all rights reserved
please note
The information contained in this communication is
confidential, may be attorney-client privileged, may
constitute inside information, and is intended only for
the use of the addressee. It is the property of
JEE
Unauthorized use, disclosure or copying of this
communication or any part thereof is strictly prohibited
and may be unlawful. If you have received this
communication in error, please notify us immediately by
return e-mail or by e-mail to jea@gmail.com, and
destroy this communication and all copies thereof,
including all attachments. copyright -all rights reserved
EFTA00686085